Always the correct part
We know our products
1 year warranty
Free Shipping to the USA
Free shipping on all orders
For VW JETTA 2.5L 05-14 Golf 10-14 Passat R32 08 DOUBLE PULLEY AC Compressor
●  Over $169, $15 OFF, Code: NEW15
●  Over $229, $25 OFF, Code: NEW25
●  Over $409, $50 OFF, Code: NEW50
NOTE: Each AC air compressor comes with about 80ML of Oil. You dont need to add oil additionally.
AUDI TT 2012-2013
VOLKSWAGEN BEETLE 2006-2014
VOLKSWAGEN BEETLE CABRIO 2010
VOLKSWAGEN GOLF 2010-2014
VOLKSWAGEN JETTA 2005-2014
VOLKSWAGEN PASSAT 2012-2014
VOLKSWAGEN R32 2008
VOLKSWAGEN RABBIT 2006-2009
Interchange Part Number:
Be sure to clean the air conditioning system before installation, otherwise it will cause compression broken.
1. Remove compressor:
Remove the A/C belt from the A/C compressor pulley. May involve loosening the belt tensioner (if equipped).
2.receiver drier or accumulator, orifice tube or expansion valve.
3.Disconnect the negative battery cable.
4.Remove the bolt that secures refrigerant lines to the A/C compressor. Inspect A/C lines for any contamination such as metal or excessive dirt inside of them. If you find any
contamination the system will need to be cleaned.Flush the condenser and evaporator using NON-OIL BASED A/C flush. On expansion valve systems. The valve must be removed before
the evaporator can be flushed. Flushed condensers from outlet to inlet and evaporators from inlet to outlet.
5.Drain all the oil from the new compressor ,if you compressor has a drain plug you will need to open it up and drain what oil is in there too.
6.Install half oil charge into the compressor and the remainder throughout the system. Turn compressor shaft 8-10 full revolutions to insure front seal and other internal
parts are lubricated.
7.Install new receiver drier or accumulator and new orifice tube or expansion valve.
8.Evacuate the A/C system for a minimum of one hour.
9.After evacuation install half the refrigerant charge and let the system set for 1 minute. This will allow the refrigerant to pick up oil and spread more evenly throughout
10.Turn on the A/C system with the engine running and check to see if cold air is now coming out of the air duct.
11.If the A/C system is functioning ,you may find that your electric radiator fan and compressor clutch will be cycling off and on depending on the outside air temperature.
To confirm that this part fits your vehicle, enter your vehicle's Year, Make, Model, Trim and Engine in the Compatibility Table.
This compressor comes pre-filled with the correct amount of oil. Thus, there is no need to add any additional oil to your system.
Please add refrigerant to 70-80% without filling up.
There may be noise if the refrigerant is added too much.
RETURNIf you are not completely satisfied with your purchase, we will be happy to accept a return for a refund or exchange on products in new/unused condition within 30 days of delivery. All authorized returns must be unused and in their original condition, including all items and components that were included in the original package. Items being returned must not have been disassembled, mounted, modified, or damaged due to incorrect installation or user error. LABWORKAUTO.com will not be held responsible for installation or labor expenses, towing expenses, additional repair expenses, or rental car expenses caused by the use of wrong or defective parts during installation.
We provide a limited warranty of 1 year for defective products from the date the product is received by the original purchaser or installer, unless otherwise specified at the time of purchase.When there is a problem with our products during the warranty period, we will try to send you a new set of products to enhance the shopping experience of every customer who purchases our products.
For each of our product warranties offered above, the following provisions apply:
The warranty is limited only to the original purchaser and is non-transferable.
Under NO circumstances will our liability exceed the amount of the original sale.
Each warranty does not cover any labor costs or incidental, indirect, special or consequential damages such as, but not limited to, physical injuries or property damage, loss of time, loss of use of the vehicle, inconvenience, air freight charges, rental vehicle charges, towing charges or accommodations resulting from a defect in or failure of the part.
A prepaid shipping label will be issued for all returns due to warranty claim.
The warranty does not cover lost or stolen packages. Because the customer is the shipper, he/she is the only one who can file any lost claim with the shipping company. Therefore, the claim must be coordinated and processed through the shipping company by the customer.